濟南卷簾門在日常使用中，受氣候條件、使用頻率及維護狀況影響，容易出現各類問題，這些問題不僅影響使用便捷性，還可能帶來隱患，了解常見問題及成因有助于及時排查處理。

　　Jinan rolling shutter doors are prone to various problems in daily use due to climate conditions, frequency of use, and maintenance conditions. These problems not only affect the convenience of use, but may also pose safety hazards. Understanding common problems and their causes can help to promptly investigate and handle them.

　　機械傳動方面的問題較為常見。卷軸與導軌是易出故障的部位，濟南春季多風沙，沙塵進入卷軸軸承后，會加劇部件磨損，導致卷簾門升降時出現卡頓、異響（如 “嘎吱” 聲），嚴重時甚無法順暢移動。導軌若安裝不平整或長期受力變形，會使簾片在滑動過程中與導軌內側摩擦，出現側邊磨損（簾片邊緣出現毛刺），若摩擦過度，還可能導致簾片卡滯，需反復施加外力才能勉強升降。此外，卷軸兩端的平衡彈簧是關鍵部件，長期使用后會因疲勞出現彈力下降，導致卷簾門升降時兩端受力不均，表現為一側下降速度快、一側慢，甚出現傾斜，這種情況在濟南夏季高溫環境下更易發生（高溫會加速彈簧老化）。

　　Mechanical transmission issues are quite common. The scroll and guide rail are prone to malfunctions. In spring, Jinan is prone to sandstorms, and when sand and dust enter the scroll bearings, it can exacerbate component wear, resulting in lagging and abnormal sounds (such as "creaking" sounds) when the rolling shutter door is lifted or lowered. In severe cases, it may even be unable to move smoothly. If the guide rail is installed unevenly or deformed under long-term stress, it will cause the curtain to rub against the inner side of the guide rail during the sliding process, resulting in side wear (burrs on the edge of the curtain). If the friction is excessive, it may also cause the curtain to jam and require repeated external force to barely lift and lower. In addition, the balance springs at both ends of the scroll are key components. After long-term use, the elasticity may decrease due to fatigue, resulting in uneven force on both ends when the rolling shutter door is lifted and lowered. This is manifested as one side descending faster and the other side descending slower, and even tilting. This situation is more likely to occur in the high temperature environment of Jinan in summer (high temperature will accelerate spring aging).

　　電氣系統故障多與環境因素相關。控制電機是卷簾門的動力核心，濟南夏季多雨潮濕，若電機接線盒密封不嚴，雨水滲入后會導致短路，表現為按動開關時電機無反應，或運行中突然停止，嚴重時可能燒毀電機線圈。遙控器失靈也是常見問題，一方面可能是電池電量不足（尤其在濟南冬季低溫環境下，電池續航能力下降），另一方面可能因附近存在電磁干擾（如周邊有大功率設備運行），導致信號接收不穩定，出現按動遙控器后卷簾門延遲響應或無動作的情況。行程開關負責控制卷簾門的升降限位，若開關觸點氧化（受濟南潮濕氣候影響），會導致卷簾門無法準確停在指定位置（如升到頂部后仍嘗試上行，或下降到地面后繼續下行），長期如此會損壞電機或簾片。

　　Electrical system failures are often related to environmental factors. The control motor is the power core of the rolling shutter door. In Jinan, it is rainy and humid in summer. If the motor junction box is not sealed tightly, rainwater infiltration can cause a short circuit. This is manifested as the motor not responding when the switch is pressed, or suddenly stopping during operation. In severe cases, it may burn out the motor coil. Remote control malfunction is also a common problem. On the one hand, it may be due to insufficient battery power (especially in the low temperature environment of Jinan in winter, the battery life may decrease), and on the other hand, it may be due to electromagnetic interference nearby (such as high-power devices running nearby), resulting in unstable signal reception and delayed response or no action of the rolling shutter door after pressing the remote control. The travel switch is responsible for controlling the lifting limit of the rolling shutter door. If the switch contacts oxidize (due to the humid climate in Jinan), it will cause the rolling shutter door to fail to accurately stop at the designated position (such as attempting to move up after reaching the top or continuing to move down after descending to the ground), which will damage the motor or curtain for a long time.

　　簾片與結構件的損壞多由外力或材質問題引起。濟南冬季寒冷，若卷簾門簾片采用的是薄鋼板且未做防腐處理，容易因低溫脆化出現開裂，尤其在受到外力撞擊（如車輛剮蹭）時，簾片可能出現凹陷或斷裂。連接簾片的鉸鏈若生銹（濟南雨季濕度高易導致），會使簾片之間轉動不靈活，升降時出現卡滯，甚帶動相鄰簾片變形。底部的防墜裝置（如氣囊、鎖鉤）若保養不當，可能因部件銹蝕失效，當卷簾門意外墜落時無法及時制動，存在風險。此外，卷簾門的固定支架若松動（如膨脹螺栓受震動脫落），會導致整體結構晃動，升降時出現明顯的位移，影響使用。

　　The damage to curtains and structural components is often caused by external forces or material issues. Jinan is cold in winter, and if the roller shutter door curtain is made of thin steel plate and not treated with anti-corrosion, it is prone to cracking due to low-temperature embrittlement, especially when subjected to external impact (such as vehicle scratches), the curtain may become depressed or break. If the hinge connecting the curtain pieces rusts (which is easily caused by high humidity during the rainy season in Jinan), it will make the curtain pieces less flexible to rotate, cause jamming during lifting, and even drive adjacent curtain pieces to deform. If the bottom anti fall devices (such as airbags and locking hooks) are not properly maintained, they may fail due to component corrosion, and may not be able to brake in a timely manner when the rolling shutter door accidentally falls, posing a safety risk. In addition, if the fixed bracket of the rolling shutter door becomes loose (such as the expansion bolt falling off due to vibration), it will cause the overall structure to shake, resulting in significant displacement during lifting and lowering, which will affect the safety of use.

　　使用習慣不當也會加劇問題出現。頻繁快速操作卷簾門（短時間內連續按動升降按鈕），會使電機頻繁啟停，導致過熱保護觸發（電機自動斷電），影響正常使用；升降過程中強行用手拉動簾片，會破壞平衡彈簧的受力平衡，加速部件磨損。此外，若卷簾門軌道內堆積雜物（如落葉、塑料袋，濟南秋季落葉較多時易出現），會阻礙簾片升降，導致電機負載增大，長期過載會縮短電機使用壽命。

　　Improper usage habits can also exacerbate the occurrence of problems. Frequent and rapid operation of the rolling shutter door (continuous pressing of the lifting button in a short period of time) can cause the motor to start and stop frequently, leading to overheating protection triggering (automatic power-off of the motor) and affecting normal use; Forcefully pulling the curtain during the lifting process can disrupt the force balance of the balance spring and accelerate component wear. In addition, if debris accumulates inside the track of the rolling shutter door (such as fallen leaves and plastic bags, which are prone to occur in autumn when there are many fallen leaves in Jinan), it will hinder the lifting of the curtain, resulting in an increase in motor load. Long term overload will shorten the service life of the motor.

　　本文由濟南卷簾門友情奉獻.更多有關的知識請點擊:http://www.santoncc.cn真誠的態度.為您提供為的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from Jinan Rolling Shutter Doors For more information, please click: http://www.santoncc.cn Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.